Citroën Berlingo Electrique

From Wikipedia, the free encyclopedia

The Citroën Berlingo Electrique is a battery-powered version of the Berlingo range of vans. It has a 162 V Saft NiCd battery [1], a 28 kW Leroy Somer electric motor [2] and has a maximum speed of 95 km/h (59 mph), with a maximum range of 95 km (59 mi) in typical driving. Production of this version stopped in September 2005.

Contents

[edit] Overview

As the was designed from the outset as a petrol, diesel and electric powered vehicle, the instrumentation and controls are very similar to a petrol/diesel van.

A Citroën Berlingo
A Citroën Berlingo

[edit] Description

[edit] Transmission

The transmission is based on the automatic gearbox concept but limited to Park, Reverse, Neutral and Drive.

[edit] Ignition operation

The ignition key controls the normal expected functions of accessories, ignition circuit and startng. When the ignition key is momentarily moved to the start position the main traction battery relay is energised (causing a clunk) which allows the accelerator to move the vehicle as normal. The function of the ignition on setting of the ignition switch is slightly different than normal cars because only the stop light and the handbrake light (if the handbrake is applied) are displayed. On other cars all the indicator lights are shown to check bulb condition. This does not give confidence in the indicator effectiveness, but is not a big issue.

[edit] Instrumentation

The large energy meter display shows remaining energy as a percentage and is surprisingly accurate. The good accuracy is provided by the on board controller monitoring the Amp-hours in and out of the battery rather than the battery voltage. However, the low charge light is operated by the battery voltage. This can mean that the low energy light does not always illuminate at exactly the same percentage charge across different vehicles or even the same vehicle at different times.

[edit] Heating

In order to minimise battery usage, a petrol driven heater is fully integrated to vehicle. It typically takes 5 to 10 minutes to warm and provides excellent cabin heating. It takes several minutes for the heater to run down and will therefore continue to operate after the ignition is turned off.

[edit] Brakes

Power assisted brakes are supplied as standard. However, because the vacuum supply from the engine in-let manifold that normally supplies the brake servo is not available on an electric vehicle a dedicated vacuum pump is used. (Typical operation of the vacuum pump is on for a 10-15 seconds and off for a couple of minutes).

[edit] Power steering

Power steering is supplied as standard. However, because the continuous rotation of the engine is not available on an electric vehicle, an electric motor is used to power an power steering hydraulic pump.

[edit] Design quirks

When the very powerful regenerative braking is active the brake lights are not illuminated. This can be disconcerting for other drivers who may not notice the van slowing significant without the help of the brake lights.

The manual does not indicate that removing the charging plug before it is fully charged can illuminate the 'Electrical Fault Light' and stays on until a full trickle charge is performed. This can be quite disconcerting as the manual says you have to take it to the dealer to reset the problem. Also, you cannot, or should not, perform a fast charge when it is in this state.

[edit] Speed and range

 This article or section may contain original research or unverified claims.
Please improve the article by adding references. See the talk page for details. (November 2007)

The actual maximum miles per charge is very dependent on the driving style. Specifically the speed. This is because atmospheric drag is non-linear with speed. i.e. increasing the speed by 25% will decrease the range by 36%. To get the most range for any electric vehicle (and to some extent petrol/diesel vehicles) involves driving at the slowest practical speed.

Typical ranges are as follows.

Speed
 Range Per
Charge		 Source
56 km/h (35 mph) 96 km (60 miles) Measured by User:arsharpe
64 km/h (40 mph) 82 km (51 miles) Measured by User:arsharpe
80 km/h (50 mph) 58 km (36 miles) Estimated by User:arsharpe
96 km/h (60 mph) 48 km (30 miles) Estimated by User:arsharpe
  • As with any vehicle driving in the heavy rain increases rolling resistance and therefore decreases the miles-per-gallon for petrol/diesel and reduces the miles-per-charge for electric vehicles. Typically reduction is about 15% .

[edit] Availability

The Electrique was made available in at least the following countries.

  • United Kingdom

[edit] Servicing

The Electrique is a simple vehicle with minimal servicing requirements. Details of servicing information is available at Citroën Berlingo Electrique Service Manual

Battery watering must be done at regular intervals (approximately every 4000 miles, depending on usage) and this can be done either at a dealership or by using a kit provided by a third party.

Brush replacement should also be done according to the maintenance schedule, as serious damage will result if it is overlooked.

[edit] Common DIY enhancements

The basic Electrique does not come with rear seats or windows. It is common for owners to install a compatible (Multispace) rear seat and rear windows.

[edit] Competitors and similar vehicles

 Please help improve this section by expanding it.
Further information might be found on the talk page or at requests for expansion.

A Peugeot badged version of this vehicle was marketed as the Peugeot Partner Electric. Battery electric versions of the popular Peugeot 106 and Citroen Saxo super-minis were developed.

During the time when the Citroen Berlingo Electrique was marketed it had no other comparable goods vehicle rival. Since production ended the Nice Car Company has marketed a mini van and Modec has developed an electric commercial vehicle with a 2 tonne payload.

[edit] See also

[edit] External links

[edit] References

  1. ^ Index
  2. ^ Leroy-Somer